New Delhi, Jul 12: A preliminary report has found that the fuel supply to both engines of Air India flight AI171 was cut off within a second of each other, causing confusion in the cockpit and the airplane plummeting back to ground almost immediately after taking off.
\nThe 15-page report says that in the cockpit voice recording, one unidentified pilot asked the other why he had cut off the fuel, which the other denied.
\nOn June 12, the London-bound Boeing 787 Dreamliner began to lose thrust almost immediately after taking off from the Ahmedabad airport and ploughed into a medical college hostel, killing all but one of the 242 onboard and another 19 on ground in the deadliest aviation accident in a decade.
\nAccording to a chronology laid out in the report by Aircraft Accident Investigation Bureau, both fuel control switches \u2013 which are used to turn the engines off \u2013 were moved to the cutoff position almost immediately after takeoff.
\nThe report however did not say how this happened or who did it.
\nSoon after both fuel cutoff switches moved from RUN to CUTOFF, one second apart, a RAT pump was deployed to supply hydraulic power as both engines fell below minimum idle rate.
\nAbout 10 seconds later, Engine 1 fuel cutoff switch moved to its so-called RUN position, followed by Engine 2 four seconds later. The pilots managed to relight both engines, but only Engine 1 recovers while Engine 2 failed to build up enough power again to reverse deceleration.
\nOne of the pilots issued a \u201cMayday, Mayday, Mayday\u201d distress call but before air traffic controllers could get a response about what had gone wrong, the plane crashed just outside the Ahmedabad airport boundary having grazed some trees before plunging into a hostel packed with students.
\nAt the time the aircraft took off, the co-pilot was flying the plane, while the captain was monitoring.
\nThe time between the takeoff and the crash was only about 30 seconds.
\nThe preliminary report by AAIB released on Saturday, recommended no action for now for the operators of Boeing 787-8 planes.
\n\u201cThe aircraft achieved the maximum recorded airspeed of 180 Knots IAS at about 08:08:42 UTC (13.38 IST) and immediately thereafter, the Engine 1 and Engine 2 fuel cutoff switches transitioned from RUN to CUTOFF position one after another with a time gap of 01 sec,\u201d the report said.
\nAs per the report, the engine N1 and N2 began to decrease from their take-off values as the fuel supply to the engines was cut off.
\n\u201cIn the cockpit voice recording, one of the pilots is heard asking the other why did he cutoff. The other pilot responded that he did not do so,\u201d it said.
\nAlmost immediately after the plane lifted off the ground, CCTV footage shows a backup energy source called ram air turbine (RAT) had deployed, indicating a loss of power from the engines.
\nThe report provided only a limited picture of the interaction between the two pilots in the flight deck and also did not say how the switches could have flipped to the cutoff position during the flight.
\nNormally, flipping to cutoff, which almost immediately cuts fuel supply, is often used to turn engines off once a plane has arrived at its airport gate and in certain emergency situations, such as an engine fire. The report did not indicate there was any emergency requiring an engine cutoff.
\nThe report said both fuel switches were found in the run position at the crash site and that there had been indications of both engines relighting before the low-altitude crash.
\nIn a statement, Air India said that it \u201cstands in solidarity with the families and those affected\u201d and \u201c[continues] to mourn the loss\u201d of those killed in the accident.
\nAir India said it was \u201cworking closely with stakeholders, including regulators\u201d and \u201ccontinue to fully cooperate with the AAIB and other authorities as their investigation progresses.\u201d
\nOn its part, Boeing said: \u201cOur thoughts remain with the loved ones of the passengers and crew on board Air India Flight 171, as well as everyone affected on the ground in Ahmedabad. We continue to support the investigation and our customers.\u201d
\nThe US National Transportation Safety Board noted that there were no recommended actions in the report aimed at operators of Boeing 787 jets or the GE engines.
\nThe ill-fated flight was commanded by Sumeet Sabharwal, 56, a veteran with 30 years of experience at Air India. He had logged 15,638 flying hours, including 8,596 on the Boeing 787. He was also an Air India instructor. His co-pilot was Clive Kunder, 32, who had 3,403 hours of total experience, with 1,128 on the Dreamliner.
\nKunder was the pilot flying, while Sabharwal was the pilot monitoring.
\nThe crew had passed pre-flight breathalyser tests and were seen at the gate on CCTV before they took off, the report adds.
\nThe June 12 accident was India\u2019s worst aviation disaster in almost three decades and the industry\u2019s deadliest in 11 years, as well as the first fatal involving a Boeing Dreamliner.
\nThe investigation was conducted with assistance from the UK\u2019s Air Accident Investigation Branch and the US National Transportation Safety Board.
\nAviation experts have said it is difficult for pilots to inadvertently move the fuel switches as there is a little mechanical gate built into the switch. Switches need to be lifted up over this little gate to shut off supply. They also asked why the report made no reference to cockpit camera footage.
\nThe AAIB report cited a FAA airworthiness bulletin from 2018 on the \u201cpotential disengagement of fuel control switch locking feature\u201d on Boeing planes including the 737 and 787. The Air India jet was not inspected for the locking mechanism fault as it was never mandatory and that there has been no defect reported pertaining to the fuel control switch since 2023, it said.
\nIt said the aircraft took off at 08:08:39 UTC (13:38:39 IST) and at about 08:09:05 UTC (13:39:05 IST) one of the pilots transmitted \u2018MAYDAY MAYDAY MAYDAY\u2019.
\n\u201cThe ATCO (Air Traffic Controller) enquired about the call sign. ATCO did not get any response but observed the aircraft crashing outside the airport boundary and activated the emergency response,\u201d the report said.
\nIn the report, AAIB also said fuel samples taken from bowsers and tanks used to refuel the aircraft were tested at the DGCA (Directorate General of Civil Aviation) Lab and were found satisfactory.
\nThe preliminary report was widely anticipated to throw more light on what could have led to the crash.
\nThe AAIB said the wreckage site activities, including drone photography\/ videography have been completed and the wreckage has been moved to a secure area near the airport.
\n\u201cBoth engines were retrieved from the wreckage site and quarantined at a hangar in the airport. Components of interest for further examinations have been identified and quarantined,\u201d it said.
\nAccording to the report, fuel samples taken from the bowsers and tanks used to refuel the aircraft were tested at the DGCA\u2019s Lab and were found satisfactory.
\n\u201cVery limited amount of fuel samples could be retrieved from the APU filter and Refuel\/Jettison valve of the left wing. The testing of these samples will be done at a suitable facility capable of carrying out the test with the limited available quantity,\u201d it said.
\nThe AAIB is gathering additional details based on initial leads and data downloaded from the forward Enhanced Airborne Flight Recorder (EAFR) is being analysed.
\n\u201cAt this stage of investigation, there are no recommended actions to B787-8 and\/or GE GEnx-1B engine operators and manufacturers,\u201d the report said.
\nThe plane that crashed was powered by GEnx-1B engines.
\nStatements of the witnesses and the surviving passenger have been obtained by the investigators.
\nThe complete analysis of post-mortem reports of the crew and the passengers is being undertaken to corroborate aeromedical findings with the engineering appreciation, the AAIB said.
\nThe probe is continuing and the investigation team will review and examine additional evidence, records and information that is being sought from the stakeholders.
\nThere were 230 passengers on board \u2014 15 in the business class and 215, including two infants, in economy class.
\nThe Pilot In Command (PIC) had more than 15,638 hours of flying experience while the first officer had over 3,403 hours of flying experience. (Agencies)<\/p>\n","protected":false},"excerpt":{"rendered":"
New Delhi, Jul 12: A preliminary report has found that the fuel supply to both engines of Air India flight AI171 was cut off within a…<\/p>\n","protected":false},"author":1,"featured_media":61835,"comment_status":"open","ping_status":"open","sticky":false,"template":"","format":"standard","meta":{"footnotes":""},"categories":[22],"tags":[],"class_list":["post-61831","post","has-post-thumbnail","category-national"],"_links":{"self":[{"href":"https:\/\/earlypostdaily.com\/index.php\/wp-json\/wp\/v2\/posts\/61831","targetHints":{"allow":["GET"]}}],"collection":[{"href":"https:\/\/earlypostdaily.com\/index.php\/wp-json\/wp\/v2\/posts"}],"about":[{"href":"https:\/\/earlypostdaily.com\/index.php\/wp-json\/wp\/v2\/types\/post"}],"author":[{"embeddable":true,"href":"https:\/\/earlypostdaily.com\/index.php\/wp-json\/wp\/v2\/users\/1"}],"replies":[{"embeddable":true,"href":"https:\/\/earlypostdaily.com\/index.php\/wp-json\/wp\/v2\/comments?post=61831"}],"version-history":[{"count":1,"href":"https:\/\/earlypostdaily.com\/index.php\/wp-json\/wp\/v2\/posts\/61831\/revisions"}],"predecessor-version":[{"id":61833,"href":"https:\/\/earlypostdaily.com\/index.php\/wp-json\/wp\/v2\/posts\/61831\/revisions\/61833"}],"wp:featuredmedia":[{"embeddable":true,"href":"https:\/\/earlypostdaily.com\/index.php\/wp-json\/wp\/v2\/media\/61835"}],"wp:attachment":[{"href":"https:\/\/earlypostdaily.com\/index.php\/wp-json\/wp\/v2\/media?parent=61831"}],"wp:term":[{"taxonomy":"category","embeddable":true,"href":"https:\/\/earlypostdaily.com\/index.php\/wp-json\/wp\/v2\/categories?post=61831"},{"taxonomy":"post_tag","embeddable":true,"href":"https:\/\/earlypostdaily.com\/index.php\/wp-json\/wp\/v2\/tags?post=61831"}],"curies":[{"name":"wp","href":"https:\/\/api.w.org\/{rel}","templated":true}]}}